果蔬清洗機采用沖浪的方式清洗，清洗機底部帶有氣泡發生裝置，使清洗機內的水翻滾帶動果蔬翻滾，將果蔬表面的塵土等清洗干凈，清洗機上方帶有高壓噴淋裝置，高壓噴淋裝置的水使用清洗機內部的水（由循環水泵抽到噴淋管）。清洗機帶有內膽裝置，方便清洗工作完成后衛生清理工作。
The fruit and vegetable cleaning machine is cleaned by surfing. There is a bubble generating device at the bottom of the cleaning machine to make the water in the cleaning machine roll, drive the fruit and vegetable to roll, and clean the dust on the surface of the fruit and vegetable. There is a high-pressure spray device above the cleaning machine. The water of the high-pressure spray device uses the water inside the cleaning machine (pumped to the spray pipe by the circulating water pump). The cleaning machine is equipped with inner tank device, which is convenient for sanitary cleaning after cleaning.
果蔬加工流程有：清洗--漂燙--風干除水--冷凍。
The processing flow of fruits and vegetables includes: Cleaning - blanching - air drying, water removal - freezing.
果蔬請機洗使用方法：
Please machine wash fruits and vegetables. Usage:
果蔬清洗機在使用時應先把清洗內加滿水，再把主電源線接在清洗機控制箱上，接好線后先打開輸送開關看是否接線接反。使用時，先打開輸送開關，再打開水泵開關，將果蔬慢慢的倒入清洗機內進行清洗。清洗完成的果蔬由輸送網帶輸送到下道工序。
When using the fruit and vegetable washer, fill the washer with water first, and then connect the main power line to the control box of the washer. After connecting the line, first turn on the transmission switch to see if the wiring is reversed. When in use, first turn on the conveying switch, then turn on the water pump switch, and slowly pour the fruits and vegetables into the cleaning machine for cleaning. The cleaned fruits and vegetables are transported to the next process by the conveyor belt.
果蔬清洗機每次使用完成后關閉急停開關。需用清水沖洗干凈，再用干凈的抹布擦拭干凈。使用一段時間后，看清洗機輸送網帶是否松動，如有松動，打開清洗機進料口的入料滑板，通過調節漲緊的漲緊開關將網帶調節到合適的松緊。
Turn off the emergency stop switch after each use of the fruit and vegetable washing machine. Clean it with clean water and wipe it with a clean rag. After using for a period of time, check whether the conveying mesh belt of the cleaning machine is loose. If it is loose, open the feeding sliding plate at the feeding inlet of the cleaning machine, and adjust the mesh belt to the appropriate tightness by adjusting the tension switch.
蔬菜清洗機360度對蔬菜進行噴淋清洗作業，可以快速的清洗掉蔬菜外表的殘留胡須、蟲子、泥土等等，網帶帶動蔬菜向前的同時，蔬菜本身在滾杠式網帶上面停止翻騰，整機規劃完好。
The vegetable cleaning machine can spray and clean the vegetables 360 degrees, which can quickly clean the residual beard, insects, soil, etc. on the surface of the vegetables. While the mesh belt drives the vegetables forward, the vegetables themselves stop tumbling on the roller mesh belt, and the whole machine is well planned.
與蔬菜清洗機主動銜接成為流水線，前后搭接完好，漂燙定色時間及溫度可自由操控，客戶根據自由工藝進行參數設定，該機可以根據客戶的理論消費情況，設置為蒸汽加熱或者電加熱，風干后，能將物料表面的水分去掉，期間經過多次翻身瀝水。
It is actively connected with the vegetable cleaning machine to form an assembly line. The front and rear laps are intact, and the bleaching and fixing time and temperature can be controlled freely. The customer can set the parameters according to the free process. The machine can be set to steam heating or electric heating according to the customer's theoretical consumption. After air drying, the water on the material surface can be removed, and it can be turned over and drained for many times.
蔬菜清洗機上部高壓強冷風吹，使軟包裝抵達表面水珠吹干的效果，袋面皺紋間的存水也精干，經風干機發出的氣流經噴嘴噴發而出，吹干風溫為常溫，風干機有用維護物料自身的色澤和質量。
The high-pressure strong cold air on the upper part of the vegetable cleaning machine can make the soft packaging reach the effect of drying the water droplets on the surface, and the water stored between the wrinkles on the bag surface is also lean. The air flow sent out by the air dryer is erupted through the nozzle, and the drying air temperature is normal temperature. The air dryer is useful to maintain the color and quality of the materials.
深加工設備主動化系統操控辦法，系統對蔬菜加工的操控包括了監視、報警、缺點診斷、斷電維護等功用，各種或許呈現的情況都會有對應的處理辦法，在遇到過載、過壓、過流、短路等電力缺點時，能主動采用維護措施，避免和減少人身與蔬菜清洗機的事故，進步提升設備的運用性。
The application of various methods of automatic monitoring and maintenance of the vegetable processing system may reduce the shortcomings of the automatic control and maintenance of the vegetable processing system, such as the lack of power, which can reduce the overload of the equipment and improve the fault of the automatic control and maintenance system, including the use of automatic monitoring and maintenance of the vegetable processing system.
以上就是為大家介紹的有關果蔬清洗機的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://wwwchinafoodjxcom/
The above is a detailed introduction to the fruit and vegetable cleaning machine. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://wwwchinafoodjxcom/